2004 Ford F-150 Front Problems
- 20
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Among these 20 stored complaint records:
- 1 indicate a crash
- 1 indicate injury
- 0 indicate fire
What owners report
- steering wheel · 5 records
- both front · 4 records
Mileage in stored records
| Band | Records |
|---|---|
| 1–30k mi | 8 |
| 60–100k mi | 3 |
| 30–60k mi | 2 |
| 100–150k mi | 1 |
Complaint records
Owner-submitted complaint content, presented as stored.
Front
No event leading to failure - to my knowledge poor handling, uneven tire wear, discovered both front springs broken at 120,000 miles truck is used pretty much as a passenger vehicle currently replacing both front springs. *tr
ODI 10415584
Front
My truck is a 2004 ford f150 fx4, the suspension on the front is bad. I bought it with 65,000 miles and it was bad. I have had to replace it after nearly hitting a semi head-on after hitting a bump and it about bounced me off of the road. This has been an ongoing problem that i couldn't figure out at first. I have called ford corporate office with no return phone call. After looking on the internet at the forums…
ODI 10384831
Front
Tl*the contact owns a 2004 ford f-150. While examining the vehicle, the contact noticed that the inside of both front tires was wearing unevenly. The contact replaced the tires and took the vehicle to an authorized dealer to have an alignment performed. The contact was informed that the alignment could not be done because both front ball joints were worn. The ball joints were not replaced but the tires were balanced…
ODI 10365501
Front
While rotating the tires on my 2004 f-150 i noticed the drivers side front coil spring was broken. I then looked at the passenger side and seen that one was broken also. I was broke in the exact same spot as the other one. I have never taken this truck off the road. It only has 75000 miles on it i think these springs should not be broken and there is a problem with them. While looking online i noticed alot of other…
ODI 10365603
Driveline · Front · Parking Brake
My 2004 ford f 150 fx 4 regular cab flareside pickup which currently has 36,000 miles has a massive vibration / shuddering while under acceleration past forty miles per hour ; i have already taken the vehicle to the dealer where they told me that it was an emergency brake problem after getting fixed the problem occurred less than a week later ; it is going back into the dealer again to get rediagnosed and cost even…
ODI 10312268
Front
2004/5 ford f150, 33,000 road miles (never been off road) parked at traffic lights in my truck when the front drivers side coils spring collapsed. Having inspected the failed part, it has not failed in the normal fracture straight through the coil but diagonally through it, surely this must be a manufacturing flaw. So glad i was stationary when it happened. *tr
ODI 10232384
Front
My accident in a parking deck is on security recording at the beau rivage casino in biloxi, ms i think. Ford cannot explain why a wheel broke off at 8 mph. I caught an 18" h x 6" w x 24' l steel traffic control device with the outside edge of my front driver's side tire. I don't know how fast i was going but the tape does. I think it less than 10 mph. I am pretty sure i was braking when it happened. I was on a down…
Crash reported · 1 injury
ODI 10195121
Front
Dt: the contact stated while driving vehicle became impossible to steer. He pulled the vehicle over and had it towed to a dealership. They found the front driver side wheel tilted in, and the ball joint nut was missing. The vehicle is currently getting repaired at the dealership.*ak
ODI 10145725
Front
Dt: contact states at speeds of 65 mph, the steering wheel starts to shimmy back and forth. The vehicle has been to the service dealer 3 times. They replaced one tire and a steering wheel dampener. This did not remedy the problem. The service dealer said they would send an engineer to the dealership next week to inspect the vehicle. The service dealer emphasized that the problem poses no safety danger. *ak
ODI 10132608
Front
Vehicle seems to wander on its own every once in a while...at first i thought it could be the wind but after it first caught my attention i watched closer and it just sort of pulls at times to one side..don't think its the tires cause they were checked at a dealership not long ago..this truck seems to have alot of problems..won't buy another one
ODI 10114632
Front
Front end of the vehicle started shook uncontrollably. Consumer was able to maintain control of the vehicle, and drove it to the dealer for inspection. Mechanic could not duplicate the problem. *ak
ODI 10099799
Front
While driving at any speed vehicle vibrated uncontrollably. Driver was able to maintain control of the vehicle, and drove it to the dealer for inspection. However, mechanic could not duplicate the problem. *ak the consumer stated that the vehicle bucked and bounced for 7 miles on asphalt. Dealer checked the vehicle 5 times and the problem was not found. *tc
ODI 10109108
Front
While driving 40 mph, the vehicle vibrated uncontrollably. The driver was able to maintain control of the vehicle and drove it to the dealer for inspection. The mechanic informed the driver that all four times needed to be replaced and replaced it. However, the problem still occurs at this time. Please provide further details. *nm
ODI 10113063
Front
While driving 60 mph vibration came from the front end. Dealership was notified, but did not resolve the problem. *ak
ODI 10101282
Front · Rack And Pinion · Tires
Dt: the contact owns a 2004 ford f150 super cab. The contact complained about steering problems. Took vehicle to the dealership several times, and they have been unable to correct the problem. Vehicle will shimmied while going down the road, they replaced the rack and pinion and it helped some. The tires have been changed, realigned, and balanced, and nothing helped. He did know of other people that also had this…
ODI 10135980
Front
Front suspension vibrates violently enough that the windshield wipers come off the glass. Problem occurs at all speeds but is worse at about 40 mph. It last any where from one quarter of a mile to four miles and then stops. It comes and goes with no warning and there is no build up to the violent shakin. It stops as fast as it starts.*ak
ODI 10086216
Front
While driving front end vibrated heavily. Dealership was notified, but did not resolve the problem. *ak
ODI 10083204
Automatic Transmission · Brake Lights · Door · Electrical System · Emission Control · Front · Fuel Gauge System · Fuel Pump
The emission light came on. The vehicle was taken to the dealer, and consumer was told that fuel pump was defective. The gauge went out of control. After filling the tank, the gauge read empty. *ak the brake light wiring was inoperative, alignment was out, the vehicle had stuck in park, the right passenger door was inoperative, the speedometer read wrong, and the vehicle would die out. *sc
ODI 10089691
Front
Very noticeable steering wheel vibration at 65 mph & very bad steering wheel shimmy when bumps are encountered during every day driving. The tires feel like they lose contact with the road & feel very unstable. *ak
ODI 10056910
Front
I purchased my 2004 ford f-150 lariat oct 2003.the front end and steering wheel vibrates at speeds of 68 to 72 mph. I have taken it back to the dealer on numerous occations, and the problem still exits.i have been told that(1)all trucks vibrate(2)after taking the truck they stated that there was nothing else they could do.*ak
ODI 10104278