2006 Ford F-150 Fuel/Propulsion System Problems
- 23
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
What owners report
- fuel pump · 15 records
- control module · 8 records
- spark plugs · 6 records
- pump control · 5 records
- pump module · 5 records
Mileage in stored records
| Band | Records |
|---|---|
| 100–150k mi | 10 |
| 60–100k mi | 9 |
| 150–400k mi | 1 |
| 30–60k mi | 1 |
| 1–30k mi | 1 |
Complaint records
Owner-submitted complaint content, presented as stored.
Electrical System · Engine · Fuel/Propulsion System
MOTOR IS MISSING AND THE CODES ARE P0345, P0349 AND P0171
ODI 11163346
Engine · Fuel/Propulsion System · Service Brakes
Ford f150 xlt 2006 should have a mandatory safety recall for the fuel control module. This is clearly a design defect and a major safety concern. I was driving down vt116 (a hilly, winding 2 lane country highway with no shoulder) in the rain at about 40mph when my truck started to buck and lose power. There was no place to pull over, so i put my hazards on and tried to limp it to a safe place to pull over. The…
ODI 10993883
Fuel Pump · Fuel/Propulsion System
Fuel pump control module corrosion causing engine to stall and not restart while driving on secondary road. *tr
ODI 10948553
Fuel/Propulsion System · Structure
While in passing lane of three lane west bound route 3 engine shut down, had to negotiate two lanes of highway traffic to get to shoulder while coasting. Vehicle towed to repair shop. Fuel pump control module failure. Module corroded, holes thru back of module where it mounts to frame. *tr
ODI 10701239
Engine · Fuel/Propulsion System · Service Brakes
2006 f-150 lost all power function while traveling down the interstate. I lost power steering and brakes. The cause is a corrosive fuel pump control module. After taking with my local ford dealer i was made aware that this is major safety issue and one that fmc refuses to recognize. This incident could have resulted in a major accident. I was lucky enough to be able to signal to the cars around me that i was having…
ODI 10693652
Fuel/Propulsion System
The engine bucks,misses and doesn't come up to speed. There is no advanced warning as when this will happen, thus making pulling out into traffic a hazard! The garage where i had the problem fixed was surprised to hear my description of my trouble. They had a f150 in the week before with the same issue!! This gentleman's truck actually shut off in traffic,so i consider myself lucky! *tr
ODI 10683601
Fuel/Propulsion System
Vehicle suddenly stalled while driving. Was able to coast to a stop and pulled over, but was stuck in a busy intersection for 15-20 minutes before the truck would restart. Was able to make it to a parking lot before it stalled again. Towed to a dealership was informed it was a corroded fuel control module. Doing a little research confirmed this is a very common problem and should be addressed as a potentially…
ODI 10663594
Fuel/Propulsion System
Part #4l3z 9d370 a (control unit) this is the fuel pump driver module on a 2006 ford f150 that failed because the shell that holds the micro chips rusted out. This should be noted to ford motor company because is a common problem in cold weather states. P.s. Repair cost at ford dealership $458.78. *tr
ODI 10644239
Fuel/Propulsion System
Tl* the contact owns a 2006 ford f-150. The contact stated that while driving at 60 mph, the vehicle stalled. The vehicle restarted but the failure recurred on numerous occasions. The vehicle was taken to a dealer for diagnostic testing. The technician diagnosed that the fuel pump control module needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure. The failure mileage was…
ODI 10663810
Fuel/Propulsion System
Upon attempting to start my 2006 ford f150 super crew cab vehicle (5.4l), the engine will attempt to crank over but will not turn on. Upon further diagnosis, it was determined that the fuel pump module is not working. It became completely rusty and exhibits holes throughout the surface of the module. This appears to be an extremely common problem that ford is very well aware of and has not addressed the problem. I…
ODI 10610729
Engine · Fuel/Propulsion System
When driving home, check engine light started flashing, immediately stopped and had vehicle towed to a well reputable shop for diagnosis and repair. Was diagnosed with two fuel injectors failing and needing replaced along with all spark plugs needed replaced. 6 of the 8 plugs snapped in half and needed to be burrowed out on top of it costing $90 per plug drilling out. Total for repairs came to $2300. But after…
ODI 10559991
Fuel/Propulsion System
Driving east on i90 (about 20 miles west of stewartville, mn) during freak may blizzard. Due to road conditions, could only drive between 15-40 mph. Suddenly the engine stopped running. I was able to start it up again and drive about 3 minutes and then it would die again. There was no place to pull over, as the shoulders of the road were not cleared and there was 12" of wet heavy snow. My truck is not 4wd so we…
ODI 10510498
Engine · Fuel/Propulsion System
The vehicle was being driven at 35 mph and simply stopped running. Vehicle could not be re-started. Towed to repair shop. The mechanic tested the fuel system and determined the fuel pump had burned out. The fuel pump was replaced at a cost of $552.05. One day after repairs were completed the check engine warning light was activated and the code revealed a fuel system issue. The vehicle was immediately taken back to…
ODI 10519483
Fuel/Propulsion System
Tl* the contact owns a 2006 ford f-150. The contact stated that while reversing at 3 mph, the vehicle stalled and would not restart. An independent mechanic diagnosed the vehicle as having a faulty fuel pump and/or faulty fuel driver module. The manufacturer was notified but offered no assistance. The vehicle had not been repaired. The vin was unavailable. The failure and current mileage was 103,000.
ODI 10509540
Fuel/Propulsion System
Tl* the contact owns a 2006 ford f-150. The contact stated that while traveling 44 mph, the vehicle shook violently then stalled. The vehicle was restarted and the failure recurred several times. The vehicle was towed to a dealer where it confirmed that the fuel pump had failed. The vehicle was repaired. The manufacturer was not contacted about the failure. The failure mileage was 111,600. The vin was unavailable.
ODI 10508729
Fuel/Propulsion System
I was warming the vehicle to go to work, my truck just suddenly stalled, had to get a tow to the nearest ford dealer, the mechanic said the fuel pump module unit went out, the part is on back order or emergency order, i have no vehicle to get to work, i need my vehicle, this part should be on recall for ford f150. *tr
ODI 10508696
Fuel/Propulsion System
Fuel pump module, enough said ford. Time to make a recall. No recall but there's an update to mount it on studs...think there's an issue? *tr
ODI 10504090
Fuel/Propulsion System
I recently purchased this vehicle used but the body was in great condition and it ran good on the test drive. After three days i noticed a fuel smell in the cab and when overtaking a vehicle it started miss fire. Fortunately the dealer i bought it from had me take it to the mechanic here in town who said that it was the number five ignition coil which he replaced. The next day the problem continued so i took it back…
ODI 10504067
Fuel/Propulsion System
Truck keeps shutting off. If you wait 45 minutes to restart it will start and idle for about 15 seconds and slowly die. Or you can drive a short distance and it will die. Repair is for the fuel pump control module. Because of where it is mounted on the truck it corrodes very fast especially in snow states due to the salt on roadways. Ford can you please do a recall of this part and reimburse us for the cost! *tr
ODI 10494978
Fuel/Propulsion System
2006 f-150 fuel control module should be a mandatory safety recall for ford. The 2006 f-150 has a poorly designed fuel module that absolutely will fail over time in rust belt states, producing a loss of power, inability to start or a complete engine stall / loss of control at any speed, including highway speeds. My complaint starts after the first snowstorm this year. The truck was sluggish to accelerate on the…
ODI 10491008
Fuel/Propulsion System
I was driving towards work when all the sudden the truck died. After safely pulling on the side of the road. The truck did not start at all. According to my family mechanic, it was the fuel pump. I paid 540 for the fix including the part from the ford dealership. A few days later, the truck did not start on the morning going to work. My family mechanic came and did a few test and found out it was the fuel pump…
ODI 10484979
Electrical System · Engine · Fuel/Propulsion System
2006 ford f-150 harley davidson has coil misfire problem. All eight coils have been replaced in the last 24 months and three have been replaced twice. Cat converter has been replaced twice in the same time period. All plugs have been replaced. The car continues to misfire. As a result, the vehicle has an extremely strong odor of fuel resonating. The dealer states that they cannot do anything to find the root of the…
ODI 10503641
Electrical System · Engine · Fuel/Propulsion System
Spark plugs on the 5.3 liter engine when replaced break--in return the book said pull engine and pull heads to replace spark plugs. The law suit filled ford admits to bad decision on spark plugs and will reimburse some of the cost. The cost is very high--the book and ford's shop said the engine needs to be pulled to pull the heads to replace the spark plugs. There was never any software updates, and now the vehicle…
ODI 10776527